89Sxx development board production instructions

Single-sided programmable Flash-based microcontroller in the system, 89Sxx series development board

Introduction

I designed this single-sided development board to use MCS-51 microcontroller learning tools to facilitate the development of single-chip projects. 89Sxx development board features:

DIL-based design of the 89Sxx 40, 89S51/52/53

In System Programming (ISP), through a 6-pin connector

RS-232 and RS-485 serial ports (shared pins) communicate with devices such as PC serial devices

HD44780 compatible alphanumeric LCD backlight control connection

The motherboard integrates 4 tact switches

16 general purpose IO port pins 5x2 headers (PORT0 and PORT2)

24CXX I2C EEPROM

Serial Real Time Clock (RTC) Backup Battery for the DS1302

Power rectification and voltage regulator on the board

Single-sided PCB design

Hardware

The hardware block diagram is shown in Figure 1. The MCU is a 89Sxx microcontroller. And the complete hardware schematic is shown in Figure 2.

P1 port as data bus is used for liquid crystal display (4-bit interface, printed circuit board layout is designed with 16X2 characters with backlight), on-board tact switch and connection in system programming (ISP)

PORT0 and general purpose IO port 2 for connecting external devices. PORT0 is connected to DIP switch, P0.0 and P0.1 are connected to opto-isolated input

Port 3, P3.0 and P3.1 are using the serial communication UART and P3.2 is the RS-485 control direction. P3.3 and P3.4 are used as general purpose IO port pins. Another pin that communicates with serial chips, EEPROM, RTC and serial shift registers (LED array indicators)

Auto Mini Halogen Lamps

Mini halogen lamp used quartz as glass shell and filled with halogen and it is smaller than halogen headlight. The mini halogen bulb is filled halogen, so it has a better luminous power and life hour than the average medium and small light bulb. The manufacture cost of mini halogen bulb is also higher than the normal vacuum bulb. Gas filled bulb is better than vacuum bulb in many different ways. The only disadvantage of gas filled is cost. Gas filled bulb can last much longer time than the vacuum one, so gas filled bulb has better cost performance. The halogen lamp is made of tungsten, but it is enclosed in a smaller quartz glass shell. Because the glass is very close to the filament, if it's made by normal glass, it will melt very easily.

Auto Mini Halogen Lamps

Auto Mini Halogen Lamps,Mini Lamp 0.3W Colored,LED Fog Lamp,Room Decorative Lamp

Heshan Jianhao Lighting Industrial Co., Ltd. , https://www.sunclubtw.com

This entry was posted in on